For all of you who didn't get the battery info, here's the LONG (but edited) version of a whole lot or really useful info I got from a truly international bunch of guys. Thanks to Wally, Bob, Jim, Glenn, Jonathan,
Phil, Graham and Rex, or for country watchers, Australia, New Zealand, England and, of course, the States. I figured there was too much good info in here, some of which came to me directly, so I thought I would share the collective wisdom. Their tips, not mine.
85 AH batteries are recommended by several people. Guaranteed starts even after several weeks of no use with alarm on. Capacity is everything. The additional cost should be thought of as a saving in wasted time - well worth the extra cost.
Referring to non-spec batteries, auto electrician seem to often remark that the battery appears too small for the car. 928's are power hogs. Even the old cars have high current draws when they have all the stuff operating. Even after fixing or replacing alternators, your battery still may not hold charge properly. A number of auto electricians have diagnosed high resistance in the wiring. Easily fixed by fitting the correct battery. Some people will argue that smaller capacity batteries are overtaxed by the 928. Don't take the chance, especially, if you live in the cold. Also, in cold cranking conditions, the battery loses capacity quickly, since it's ability to hold charge is based upon a chemical reaction. A larger battery will extend the cranking time pretty significantly. That said, batteries age and lose capacity - a 90 amp/hour battery can deteriorate quite a bit more than a 60 amp/hour battery before each becomes inadequate, so the larger battery will often have a longer service life. Again, if you're not in the cold, you may be able to get away with less, but if you are moving into winter, bigger is better.
UNDER NORMAL CONDITIONS:
Under normal RUNNING conditions, the amperage used is provided by the alternator, not the battery, and the capacity of the battery (within reason, say 50 to 90 amp/hours) makes no difference. If you spend a lot of time in the dark, in the rain, with the the HVAC system on high, and idling, the alternator output is marginal, and a larger battery acts as a bigger buffer between bursts of higher speed charging operations.
In normal cranking conditions, the battery must be able to furnish about 180 amps at 10 volts for long enough to crank the car. If the car cranks quickly, even a small battery is adequate. A larger battery just adds a longer cranking cycle before the available voltage drops below the required voltage and the brain shuts down.
CHECK YOUR ALTERNATOR:
Does your battery seem to have trouble holding charge? Recharged batteries mean nothing if your alternator is on the way out. Watch for the tell-tale alternator light. It seems that on the older cars, the insulation of the internal wiring may deteriorated to the point where it shorts, and the alternator may end up drawing three amps on its own.
Here's a suggestion for future troubleshooting. Buy yourself an inexpensive VOM (Volt Ohm Meter). You want one that measures amperage to about 10 amps, too. Then, while your car is running, measure the battery voltage at the battery. It should measure around 13.8 to 14.2 volts at the battery. If it's substancially lower than that, you probably have a charging problem. I.E. bad connections or possibly a bad Voltage Regulator in your alternator. The VR is inside your alternator and not a separate unit on ALL 928 cars. Next, disconnect the negative side of your battery and place the amp meter in series with the battery post and the battery cable. Then, close the hatch switch to turn off the inside lights. Your meter should show about 20 milliamps with nothing on. If it's substancially more than that then you have a problem somewhere and you'll have to look for it. Start with a fuse pulling session in such cases to isolate the system where that is drawing the excess current. You pull a fuse and recheck your current meter. If you do these tests, you won't be guessing about your electrical system, you'll KNOW if there is or isn't a
Maintenance is the key. 8 years on the same battery! How? Plug in a battery maintainer every time you get back home if your car is not a daily driver. It may be a week, or months before you drive it again, and it's always hot and ready to crank. You can use the same battery for 8 years or more, so it really really extends your battery life. If your car is not used during the winter, you also won't have to worry about your battery freezing, because a charged battery won't freeze.
HOW TO CHARGE:
Batteries don't like being fully discharged and usually after about 6 times give up. If you have access to a good battery charger, remove the battery from the car and remove caps. Charge the battery at about 30 amps for 30 minutes then reduce to 5 to 10 amps and let the battery gas off for an hour. The electrolyte in each cell should be gassing at the same amount. If a cell has failed its all over and time to drag out the credit card.
Parts importers are cheaper than dealers.
COLD WEATHER STARTING TIPS:
If you ever get caught in cold weather, or if you suspect that you may be running out of battery capacity, you can help a 928 crank much more quickly. Just hit the starter for very short bursts rather than holding it on. The fuel pump runs for only a very short time until the engine cranks. By using short bursts, you allow fuel pressure to build up, greatly improving the chances that the engine will start quickly.
Earlier cars had the battery box attached to the gearbox/diff assembly, and used its weight to help dampen drive train vibrations. Not relevant for newer cars, and it seems that Mark A is using a Westco gelcell to save weight. I wonder if he still has the HVAC system connected . . .
DANGER WILL ROBINSON:
Watch the height of those non standard batteries! The battery box lid is NOT made of plastic. If the lid is latched down hard on the battery terminals you're putting a lot of trust on that black rubberized positive terminal cover (if you still have it).
Well - that's about it. Thanks again for those who took the time to either write to the list, or me individually. There was probably some new info in there for most of you, right?
Simon in Sapporo
84 928 S2 with new 85AH battery
928 Tips Home Greg's Home